Natural Zeolite as Mo and MoP Catalysts Support for Catalytic Deoxygenation of Jatropha Oil

Isalmi Aziz, Muhammad Farhan, Nanda Saridewi, Yulyani Nur Azizah, Anna Muawanah, Siti Nurbayti, Adid Adep Dwiatmoko, Lisa Adhani

Abstract


Non-edible oil, such as Jatropha oil, is an interesting feedstock for the development of renewable diesel (green diesel). Catalytic deoxygenation using natural zeolite-supported Mo-based catalysts is a promising process for the conversion of Jatropha oil to green diesel. Mo and MoP catalysts supported on natural zeolite were synthesized by wet impregnation at a concentration of 5% (w/w). The catalysts were characterized by XRD, XRF, SAA and NH3-TPD. The catalysts were successfully synthesized with the appearance of Mo and MoP peaks on the catalyst diffractogram. XRF results also showed that Mo and P were present in the catalyst. Metal impregnation decreased the surface area and pore volume of the catalyst, but increased the average pore diameter. The NH3-TPD profile of the catalyst showed that the weak acid sites of both catalysts were larger than the strong acid sites. Based on the activity test of catalytic deoxygenation of Jatropha oil, the MoP/HZ catalyst produced a higher conversion (67%) and liquid product yield (79%) than Mo/HZ. This is associated with a larger pore diameter, so that the distribution of reactants on the catalyst surface is more optimal. However, the highest green diesel selectivity of 82% is produced by the Mo/HZ catalyst. The Mo/HZ catalyst is more oriented towards the HDO reaction, whereas the MoP/HZ catalyst is more oriented towards the DCO/DCO2 reaction.


Keywords


Catalytic deoxygenation; green diesel; jatropha oil; natural zeolite

References


Hartanto RR, Ginting PGI, Adriawan AM, Novizar A, Patik D, Aryani D. Statistik Minyak Dan Gas Bumi 2023.; 2023.

Ruatpuia JVL, Halder G, Vanlalchhandama M, et al. Jatropha curcas oil a potential feedstock for biodiesel production: A critical review. Fuel. 2024;370(January):131829. doi:10.1016/j.fuel.2024.131829

Siregar YDI, Riyadhi A, Damayanti WA, Rizkiansyah, Murditya MB. Production of Bio hydrocarbons from Vegetable Oils and Animal Fats Using Magnesium Oxide as Catalyst. J Kim Val. 2023;9(2):195-205. doi:10.15408/jkv.v9i2.30865

Rasyid R, Prasetyo D, Fitriani N, Syarif T. Catalytic Cracking of Palm Fatty Acid Distillate with NaOH and KOH Catalyst Supported by Gamma Alumina. Int J Technol. 2024;15(3):770-779. doi:10.14716/ijtech.v15i3.5980

Dewanti AT, Rasyid R, Kalla R. Effect of HCl/γ-Al2O3 and HCl/Ni/γ-Al2O3 Catalyst on The Cracking of Palm Oil. J Kim Val. 2022;8(2):190-198. doi:10.15408/jkv.v8i2.25774

Kordulis C, Bourikas K, Gousi M, Kordouli E, Lycourghiotis A. Development of nickel based catalysts for the transformation of natural triglycerides and related compounds into green diesel: A critical review. Appl Catal B Environ. 2016;181:156-196. doi:10.1016/j.apcatb.2015.07.042

Kamaruzaman MF, Taufiq-Yap YH, Derawi D. Green diesel production from palm fatty acid distillate over SBA-15-supported nickel, cobalt, and nickel/cobalt catalysts. Biomass and Bioenergy. 2020;134(January):105476. doi:10.1016/j.biombioe.2020.105476

Aziz I, Sugita P, Darmawan N, Dwiatmoko AA, Rustyawan W. Green diesel synthesis from palm fatty acid distillate using a nickel phosphide catalyst: Optimization by box behnken design. Bioresour Technol Reports. 2024;27(June):101897. doi:10.1016/j.biteb.2024.101897

Zhang F, Tian XF, Fang Z, Shah M, Wang YT, Jiang W, Yao M. Catalytic production of Jatropha biodiesel and hydrogen with magnetic carbonaceous acid and base synthesized from Jatropha hulls. Energy Convers Manag. 2017;142:107-116. doi:10.1016/j.enconman.2017.03.026

Aziz I, Kurnianti Y, Saridewi N, Adhani L, Permata W. Utilization of Coconut Shell as Cr2O3 Catalyst Support for Catalytic Cracking of Jatropha Oil into Biofuel. J Kim Sains dan Apl. 2020;23(2):39-45. doi:10.14710/jksa.23.2.39-45

del Río JI, Cardeño F, Pérez W, Peña JD, Rios LA. Catalytic hydrotreating of jatropha oil into non-isomerized renewable diesel: Effect of catalyst type and process conditions. Chem Eng J. 2018;352(July):232-240. doi:10.1016/j.cej.2018.07.021

Vázquez-Garrido I, López-Benítez A, Guevara-Lara A, Berhault G. Synthesis of NiMo catalysts supported on Mn-Al2O3 for obtaining green diesel from waste soybean oil. Catal Today. 2021;365(May 2020):327-340. doi:10.1016/j.cattod.2020.06.001

Du X, Liang W, Hao X, Zhou K, Yang H, Lei X, Li D, Hu C. The effect of support on nickel phosphide catalysts for one-pot conversion of jatropha oil into high grade hydrocarbons. Catal Today. 2021;367(November 2019):83-94. doi:10.1016/j.cattod.2020.06.089

Tan Q, Cao Y, Li J. Prepared multifunctional catalyst Ni2P/Zr-SBA-15 and catalyzed Jatropha Oil to produce bio-aviation fuel. Renew Energy. 2020;150:370-381. doi:10.1016/j.renene.2019.12.029

Asikin-Mijan N, Lee H V., Abdulkareem-Alsultan G, Afandi A, Taufiq-Yap YH. Production of green diesel via cleaner catalytic deoxygenation of Jatropha curcas oil. J Clean Prod. 2017;167:1048-1059. doi:10.1016/j.jclepro.2016.10.023

Ramesh A, Palanichamy K, Tamizhdurai P, Umasankar S, Sureshkumar K, Shanthi K. Sulphated Zr–Al2O3 catalysts through jatropha oil to green-diesel production. Mater Lett. 2019;238(December):62-65. doi:10.1016/j.matlet.2018.11.158

Du X, Zhou K, Zhou L, Lei X, Yang H, Li D, Hu C. Efficient catalytic conversion of jatropha oil to high grade biofuel on Ni-Mo2C/MCM-41 catalysts with tuned surface properties. J Energy Chem. 2021;61:425-435. doi:10.1016/j.jechem.2021.02.006

Fauzi RA, Tursiloadi S, Dwiatmoko AA, Sukandar D, Aulia F, Rinaldi N, Sudiyarmanto. Performance of Modified Natural Zeolites by Sodium Hydroxide Treatments in The Esterification of Glycerol and Oleic Acid. J Kim Val. 2019;5(2):236-241. doi:10.15408/jkv.v5i2.9976

Kurniawan AA, Rustyawan W, Ibadurrohman M. Performance Test of Various Indonesian Natural Zeolites as Composite Components of NiMo / Al2O3-Zeolite Catalysts for Hydrocracking Used Cooking Oil into Biohydrocarbons. Bull Chem React Eng & Catal. 2025;20(1):99-108. doi:10.9767/bcrec.20254

Putra R, Lestari WW, Wibowo FR, Susanto BH. Fe/Indonesian natural zeolite as hydrodeoxygenation catalyst in green diesel production from palm oil. Bull Chem React Eng & Catal. 2018;13(x):245-255. doi:10.9767/bcrec.13.2.1382.245-255

Chintakanan P, Vitidsant T, Reubroycharoen P, Kuchonthara P, Kida T, Hinchiranan N. Bio-jet fuel range in biofuels derived from hydroconversion of palm olein over Ni/zeolite catalysts and freezing point of biofuels/Jet A-1 blends. Fuel. 2021;293(February):120472. doi:10.1016/j.fuel.2021.120472

Aziz I, Sugita P, Darmawan N, Adep A. Hydrodeoxygenation of palm fatty acid distillate ( PFAD ) over natural zeolite-supported nickel phosphide catalyst : Insight into Ni/P effect. Case Stud Chem Environ Eng. 2024;9(September 2023):100571. doi:10.1016/j.cscee.2023.100571

da Silva Neto AV, Leite ER, da Silva VT, Zotin JL, Urquieta-González EA. NiMoS HDS catalysts – The effect of the Ti and Zr incorporation into the silica support and of the catalyst preparation methodology on the orientation and activity of the formed MoS2 slabs. Appl Catal A Gen. 2016;528:74-85. doi:10.1016/j.apcata.2016.09.019

Gutiérrez OY, Singh S, Schachtl E, Kim J, Kondratieva E, Hein J, Lercher JA. Effects of the support on the performance and promotion of (Ni)MoS 2 catalysts for simultaneous hydrodenitrogenation and hydrodesulfurization. ACS Catal. 2014;4(5):1487-1499. doi:10.1021/cs500034d

Pelardy F, Daudin A, Devers E, Dupont C, Raybaud P, Brunet S. Deep HDS of FCC gasoline over alumina supported CoMoS catalyst: Inhibiting effects of carbon monoxide and water. Appl Catal B Environ. 2016;183:317-327. doi:10.1016/j.apcatb.2015.10.026

Li K, Wang R, Chen J. Hydrodeoxygenation of anisole over silica-supported Ni2P, MoP, and NiMoP catalysts. Energy and Fuels. 2011;25(3):854-863. doi:10.1021/ef101258j

Dwiratna B, Soebagjo S. Pengembangan Katalis Berbasis NiMo Alumina untuk Reaksi HidrodeoksigenasiMinyak nabati menjadi Bioavtur. J Energi dan Lingkung. 2015;11(2):75-80. doi:10.29122/elk.v11i2.1580

Hidayah N, Wijayati N, Mursiti S. Aktivitas Katalitik P2O5-Zeolit Alam pada Reaksi Hidrasi Terpentin menjadi α-Terpineol. Indones J Chem Sci. 2017;6(3):236-242.

Golubeva MA, Zakharyan EM, Maximov AL. Transition Metal Phosphides (Ni, Co, Mo, W) for Hydrodeoxygenation of Biorefinery Products (a Review). Pet Chem. 2020;60(10):1109-1128. doi:10.1134/S0965544120100047

Lu M, Zheng L, Li R, Guan Q, Li W. Efficient hydrogenation performance improvement of MoP and Ni2P catalysts by adjusting the electron distribution around Mo and Ni atoms. RSC Adv. 2016;6(69):65081-65088. doi:10.1039/c6ra09862b

Alvarez-galvan MC, Blanco-brieva G, Capel-sanchez M, Morales-delarosa S, Campos-martin JM, Fierro JLG. Metal phosphide catalysts for the hydrotreatment of non-edible vegetable oils. Catal Today. 2017;(March):0-1. doi:10.1016/j.cattod.2017.03.031

Xiao W, Wang F, Xiao G. Performance of hierarchical HZSM-5 Zeolites Prepared by NaOH Treatments in the Aromatization of Glycerol. R Soc Chem. Published online 2015. doi:10.1039/b000000x

Lee CW, Lin PY, Chen BH, Kukushkin RG, Yakovlev VA. Hydrodeoxygenation of palmitic acid over zeolite-supported nickel catalysts. Catal Today. 2021;379(May 2020):124-131. doi:10.1016/j.cattod.2020.05.013

Guo C, Rao KTV, Yuan Z, He S (Quan), Rohani S, Xu C (Charles). Hydrodeoxygenation of fast pyrolysis oil with novel activated carbon-supported NiP and CoP catalysts. Chem Eng Sci. 2018;178:248-259. doi:10.1016/j.ces.2017.12.048

Aziz I, Sugita P, Darmawan N, Adep A. Effect of desilication process on natural zeolite as Ni catalyst support on hydrodeoxygenation of palm fatty acid distillate ( PFAD ) into green diesel. South African J Chem Eng. 2023;45(July):328-338. doi:10.1016/j.sajce.2023.07.002

Usman M, Li D, Razzaq R, Yaseen M, Li C, Zhang S. Novel MoP/HY catalyst for the selective conversion of naphthalene to tetralin. J Ind Eng Chem. 2015;23:21-26. doi:10.1016/j.jiec.2014.08.033

Nie Z, Zhang Z, Chen J. Effect of Ni and noble metals (Ru, Pd and Pt) on performance of bifunctional MoP/SiO 2 for hydroconversion of methyl laurate. Appl Surf Sci. 2017;420:511-522. doi:10.1016/j.apsusc.2017.05.173

Chang H, Lee HV, Taufiq-Yap YH, Abdulkareem-Alsultan G, Seenivasagam S. Metal organic framework-derived advanced porous material supported catalysts for green diesel production from palm fatty acid distillate via deoxygenation pathways. Renew Energy. 2025;238:121882. doi:https://doi.org/10.1016/j.renene.2024.121882

Liu X, Chen J, Zhang J. Hydrodechlorination of chlorobenzene over silica-supported nickel phosphide catalysts. Ind Eng Chem Res. 2008;47(15):5362-5368. doi:10.1021/ie7017542

Gamal MS, Asikin-Mijan N, Khalit WNAW, Arumugam M, Izham SM, Taufiq-Yap YH. Effective catalytic deoxygenation of palm fatty acid distillate for green diesel production under hydrogen-free atmosphere over bimetallic catalyst CoMo supported on activated carbon. Fuel Process Technol. 2020;208(July). doi:10.1016/j.fuproc.2020.106519

Wang Z, Dornath P, Chang CC, Chen H, Fan W. Confined Synthesis of Three-Dimensionally Ordered Mesoporous-Imprinted Zeolites with Tunable Morphology and Si/Al Ratio. Microporous Mesoporous Mater. 2013;181:8-16. doi:10.1016/j.micromeso.2013.07.010

Aziz I, Adhani L, Maulana MI, Marwono MA, Dwiatmoko AA, Nurbayti S. Conversion of Nyamplung Oil into Green Diesel through Catalytic Deoxygenation using NiAg/ZH Catalyst. J Kim Val. 2022;8(2):240-250. doi:10.15408/jkv.v8i2.25943

Zarchin R, Rabaev M, Vidruk-Nehemya R, Landau M V., Herskowitz M. Hydroprocessing of soybean oil on nickel-phosphide supported catalysts. Fuel. 2015;139:684-691. doi:10.1016/j.fuel.2014.09.053

Chen L, Janssens TVW, Skoglundh M, Grönbeck H. Interpretation of NH3-TPD Profiles from Cu-CHA Using First-Principles Calculations. Top Catal. 2019;62(1-4):93-99. doi:10.1007/s11244-018-1095-y

Luo N, Cao Y, Li J, Guo W, Zhao ZW. Preparation of Ni2P/Zr-MCM-41 catalyst and its performance in the hydrodeoxygenation of Jatropha curcas oil. Ranliao Huaxue Xuebao/Journal Fuel Chem Technol. 2016;44(1):76-83. doi:10.1016/s1872-5813(16)30007-x

Ruangudomsakul M, Osakoo N, Wittayakun J, Keawkumay C, Butburee T, Youngjan S, Faungnawakij K, Poo-arporn Y, Kidkhunthod P, Khemthong P. Hydrodeoxygenation of palm oil to green diesel products on mixed-phase nickel phosphides. Mol Catal. 2022;523(May):111422. doi:10.1016/j.mcat.2021.111422


Full Text: PDF

DOI: 10.15408/jkv.v11i1.45272

Refbacks

  • There are currently no refbacks.


Copyright (c) 2025 Isalmi Aziz

Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.